|
|
|
|
Material Safety Data Sheet Zorbie Products Ltd #28-34378 Manufacturer’s Way B-100 Release Agent Abbotsford, B.C. V2S 7M1 January 2007 Tel: (888)-556-2407 Fax: (604)-557-2044
SECTION 1 IDENTITY
Product Name B100 Release Agent Product Identification Methyl ester from vegetable and/or animal oils (liquid) Distributor Zorbie Products Ltd Emergency Contact Russ Simpson @ 604-290-2218 CAS Number Not Chemical
SECTION 2 COMPONENTS & INGREDIENTS
Hazardous Components This product contains no hazardous products
SECTION 3 HAZARDOUS IDENTIFICATION
Skin Contact May cause irritation. This product can be heated at high temperatures and skin burns are possible. Ingestion No hazards are related to an accidental ingestion of this product Eye Contact Could cause irritations. Rinse with running water for at least 15-20 minutes. If symptoms persist, acquire medical assistance Inhalation This product could cause damage if heated and produced mist. Irritations to mucous membrane can be caused by fine vapors, dizziness or nausea. Breathe fresh air
SECTION 4 FIRST AID MEASURES
Skin Contact Wash the infected part of the body with soap and water Eye Contact In case of contact, flush eyes with plenty of water for at least 15 minutes using an eyewash fountain, if available. Get medical attention if irritation occurs. Inhalation Evacuate from the exposition zone, see medical support if symptoms persist Ingestion Avoid ingestion. If swallowed do not induce vomiting. Drink 2 glasses of water. B100 is 10 times less toxic than table salt.
SECTION 5 FIRE MEASURES
Flammability Flash point (method used): >130 ˚C (ASTM D93) Extinguishing methods: Foam, Co2, water and dry chemical product. Water burst can splash the fire surface and extend the fire. Special Procedures for fire: The environment at risk should be sprayed with water. Unusual Fire & Explosion Hazards: Soaked rags may cause a spontaneous combustion if not handled with care. Before disposal, you should wash rags with soap and water, let dry in well ventilated area. Fire fighters should use an air tester to avoid exposure to mist or vapors.
SECTION 6 ACCIDENTAL RELEASE MEASURES
Leak and Spill Procedures Take away from any flammable sources(if possible), Contain the spill, control the leak if possible. Clean up with absorbent pads & oil sponge. Wash any hard surface with detergent to remove all oily residues. B100 is 4 times more biodegradable than petroleum. Waste Disposal Only an approved company can pick up waste, and then shipped to an approved landfill. Conform to federal, provincial and municipal laws.
SECTION 7 HANDLING AND STORAGE
Handling Procedure & Storing Store in a closed tank between 50˚F and 120˚F. Keep away from oxidant agents, excessive heat and flame sources. Store and use in ventilated area. Do not store or use near a heat source. Do not pierce, pull or slide the barrel. The barrel is not a pressure vessel, never use pressure to empty it.
SECTION 8 EXPOSURE CONTROL / PERSONAL PROTECTION
Ventilation Use in well ventilated area Gloves Use oil/solvent resistant Respirator Use approved respiratory mask if vapors are generated Eyes Safety glasses or chemical splash goggles Other All contaminated clothing should be washed before reusing
SECTION 9 PHYSICAL AND CHEMICAL PROPERTIES
Physical State Liquid Specific Gravity (H20=1) 0.88 Steam Density (air=1) > 1 Evaporation Rate (butyl acetate=1) < 1 Boiling Point 760mm Hg > 200˚C Solubility in Water Insoluble Volatility, % per volume < 2
SECTION 10 STABILITY AND REACTIVITY
Chemical Stability This product is stable and won’t create any hazardous chain reaction Incompatibility with Other Substances Strong oxidizing agents Hazardous By-Products Emissions of carbon monoxide and carbon dioxide may occur when there is combustion
SECTION 12 TRANSPORT INFORMATION
TRANSPORT CANADA: Shipping Name Fatty Acid Ester Identification Number None Shipping classification None
NMFC (National Motor Freight Classification) Shipping Name Fatty Acid Ester Identification Number none Shipping Classification none
SECTION 13 REGULATORY INFORMATION
OSHA According to OSHA this product is not known as hazardous, OSHA 29 CFR 1910.1200. Mists and vapors that the product may generate could be hazardous as mentioned before.
TSCA All ingredients are on the TSCA Chemical Substance Inventory
CALIFORNIA PROPOSITION 65 The following statement is made in conformity with the 1986 Califonia State Law regarding the safety drinking water. This product does not contain any product that could cause any cancer known by the California State.
This information is given in good faith but no warranty, expressed or implied is made. Zorbie Products Ltd will not be liable for any damages, losses, injuries or consequential damages which may result from the use of or reliance on any information contained herein. This Material Safety Data Sheet is valid for 3 years.
|
Send mail to
webmaster@zorbieproducts.com with questions or
comments about this web site.
|
